Mechanical Properties Enhancement of Al-Si-Cu-Fe Alloy Through Aging Treatment Variations

Moch Iqbal Zaelana Muttahar, Shinta Virdhian, Purbaja Adi Putra, Dagus Resmana Djuanda, Eva Afrilinda, Amsal Genesar

Abstract

Al-Si alloys are being widely used as main engine components replacing iron in several parts in the automotive industry. Some of its mechanical properties were a reference in its alloy utilization. In this research, the heat treatment carried out on the specimen included solid solution treatment and the artificial aging process for aluminium alloys. Test pieces were heated on the furnace with a solid solution treatment process at 540 ° C with holding time around 5 hours and quenched at 60 °C with water quenchant, followed by 3 different aging treatment which included single-stage aging, artificial aging with pre-aged, and double stage aging. Tests carried out by hardness test, tensile strength test, impact test, metallographic and Scanning Electron Microscopy-Energy Dispersive Spectroscopy (SEM-EDS) observations. The results of this research showed the differences in phase constituent and morphology microconstituents due to variations of aging. The difference of each treatment could be seen in the morphology of the precipitate that is dispersed, rounded and needle-like shaped, this phase can influence the mechanical properties of Al-Si-Cu alloys. The results of mechanical testing show the highest hardness was obtained by double stage aging treatment 161.27 HRB. The highest tensile strength occurs in specimens with a single-stage aging treatment of 202.56 MPa. The highest impact resistance occurred in samples with the pre-aging treatment of 18.6 J.

Full Text:

PDF

References

J. G. Jeon, J. H. Shin, S. E. Shin, H. J. Choi, and D. H. Bae, “Recrystallized fine grains induced by nanoparticles in Al–Si–Mg–Cu-based alloy sheets,” Mater. Charact., p. 110457, 2020.

B. Lin et al., “Thermal exposure of Al-Si-Cu-Mn-Fe alloys and its contribution to high temperature mechanical properties,” Integr. Med. Res., vol. 9, no. 2, pp. 1856–1865, 2019.

S. Beroual, Z. Boumerzoug, P. Paillard, and Y. Borjon-piron, “Effects of heat treatment and addition of small amounts of Cu and Mg on the microstructure and mechanical properties of Al-Si-Cu and Al- Si-Mg cast alloys,” J. Alloys Compd., vol. 784, pp. 1026–1035, 2019.

M. Zhang, J. Wang, J. Han, H. Sui, and H. Huang, “Calphad Optimization of heat treatment process of Al – Mg – Si cast alloys with Zn additions by simulation and experimental investigations,” Calphad, vol. 67, no. October, p. 101684, 2019.

A. N. Singh, A. Moitra, P. Bhaskar, G. Sasikala, A. Dasgupta, and A. K. Bhaduri, “Materials Science & Engineering A E ff ect of thermal aging on microstructure , hardness , tensile and impact properties of Alloy 617,” Mater. Sci. Eng. A, vol. 710, no. October 2017, pp. 47–56, 2018.

A. L. Rominiyi, K. M. Oluwasegun, J. O. Olawale, M. B. Shongwe, and A. R. Adetunji, “Materials Today : Proceedings Effect of post-ECAP aging on the microstructure , hardness and impact behaviour of 6061 Al alloy,” Mater. Today Proc., no. xxxx, 2020.

M. I. Z. Muttahar, “Pengaruh Variasi Waktu Holding Proses Artificial Aging Terhadap Kekuatan Tarik Dan Ketahanan Impak Paduan Al-Si Effect Of Holding Time During Artificial Aging Of Al-Si Alloy,” vol. 41, pp. 69–74, 2019.

M. A. Afifi et al., “Effect of heat treatments on the microstructures and tensile properties of an ultrafinegrained Al-Zn-Mg alloy processed by ECAP,” J. Alloys Compd., 2018.

Y. Liu, Q. Pan, H. Li, Z. Huang, J. Ye, and M. Li, “Revealing the evolution of microstructure, mechanical property and corrosion behavior of 7A46 aluminum alloy with different ageing treatment,” J. Alloys Compd., vol. 792, pp. 32–45, 2019.

O. Engler, C. D. Marioara, Y. Aruga, M. Kozuka, and O. R. Myhr, “Materials Science & Engineering A Effect of natural ageing or pre-ageing on the evolution of precipitate structure and strength during age hardening of Al – Mg – Si alloy AA 6016,” Mater. Sci. Eng. A, vol. 759, no. April, pp. 520–529, 2019.

M. X. Guo et al., “Solute clustering in Al-Mg-Si-Cu-(Zn) alloys during aging,” 2018.

Z. Ma, E. Samuel, A. M. A. Mohamed, A. M. Samuel, F. H. Samuel, and H. W. Doty, “Influence of aging treatments and alloying additives on the hardness of Al-11Si-2.5Cu-Mg alloys,” Mater. Des., vol. 31, no. 8, pp. 3791–3803, 2010.

O. B. Umaru, M. Abdulwahab, A. Tokan, A. M. Bello, and H. A. Umar, “Effect of double thermal ageing treatment on the mechanical properties of Al-Cu-Mg/3% rice husk ash composite,” Results Phys., vol. 6, pp. 342–345, 2016.

A. M. Samuel, H. W. Doty, S. Valtierra, and F. H. Samuel, “Relationship between tensile and impact properties in Al – Si – Cu – Mg cast alloys and their fracture mechanisms,” Mater. Des., vol. 53, pp. 938–946, 2014.

O. Elsebaie, A. M. Samuel, F. H. Samuel, and H. W. Doty, “Impact toughness of Al-Si-Cu-Mg-Fe cast alloys: Effects of minor additives and aging conditions,” Mater. Des., vol. 60, pp. 496–509, 2014.

Copyright (c) 2020 Metalurgi
Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.

Refbacks

  • There are currently no refbacks.